I’ve gone on and on about the different ways to smoke meat. Finally, I am going to have to pick one and write about it.
So here we go.
First of all, I am most familiar with using a brine to cure and flavor the meat. In a bit of research about what is out there I see quite a few recipes from people that are not worried about using a cure, in addition to salt, for low heat cooking. I think this is a bit risky, especially on poultry and fish, unless you are using a fairly high salt content by today’s standards. In ideal circumstances there would be no problem, but if the meat has a higher bacteria count than normal (maybe Earl at the plant got a bit careless when moving Porkchop to the breakdown area and dropped her on the floor, giving her an unintentional marinade in unmentionables or perhaps you were distracted as you were getting the ham out to put it down in the brine and the game you gave up on became a higher priority than that special project that got a bit warmer than intended before brining) you may wish you Had upped your protection. Point is that a cure is a great insurance policy against the unknown without having to make your brine too salty. The low heat cooking process is a more favorable environment for bacteria than a normal cooking process. The meat will spend twice as long in the ideal range for bacterial growth. So I recommend incorporating a cure in any Low Heat Cooking.
The original cure used in this process is salt. However we have other preservatives we can use, so the level of salt needed is lower and more a factor of taste than necessity. These other preservatives are the dreaded Nitrites, Nitrates, and Phosphates we spent a decade or more fearing. When the big studies were conducted to put the nails in the coffin of preservatives like these, the scientists were red faced to report that there were no links between these preservatives and health problems. In fact they found that there may be some health benefits from them. So when putting together a recipe, I recommend including a cure with your other ingredients or substitute a mix like Morton’s Tender Quick. It includes salt, sugar, nitrites, and nitrates. You use a 1:4 ratio of Tender Quick to water by volume. The directions say 2 cups of Tender Quick to 8 cups of water.
Hot Smoking Similar to Barbecuing but generally done at slightly lower temperatures. Smoke can be used for adding flavor.
Kippering Devised in particular for fish, this process relies on both the curing and cooking of meat. Smoke here is also used as a flavor enhancer.
Cold Smoking The process involved the use of smoke to preserve meat. Today, cures are used to help kill bacteria and parasites. Some people will also use a period of time (3 or more days) in the freezer to eliminate parasites, especially from fish. The cure alone only slows the growth of bacteria.
If I tried to include all of the different sources that contributed to all the ways of smoking meat, we’d have a book or two not a recipe.
That having been said, how about a recipe for something.
First, a good recipe for brine.
- 1 gallon water (Hot)
- 1 cup salt
- 1/2 cup brown sugar
- 1/4 cup whole cloves (ground cloves are fine)
- 1/4 cup ground nutmeg
- 6 cinnamon sticks ( ground is fine, but I don’t have an amount for you, My guess 1/4 cup)
- 1-2 oz of liquid smoke (2-4 Tbs)
The original recipe calls for boiling the mixture. I combined the ingredients I used very hot water out of the tap and mixed it until the ingredients are dissolved as much as possible. If the ingredients aren’t dissolving as much as you would like, boil the brine for 20 minutes or so. Either way make sure the brine is cool or even cold before putting the meat down into it.
I adapted this from About.com And is by Derrick Riches.
I used this recipe because it is the most similar I have found to the recipe we used in the Smokehouse ( Yes, I added and subtracted a bit). The ingredients we used were only available commercially. This recipe does not include any cure, so here are some options. Add 1-2 oz of Tender Quick to the recipe or find a cure with no salt and follow the directions or substitute Tender Quick for the salt and the sugar.
Anytime you are making a brine or marinade you should be able to sample it and get an idea if the ratios are right. It will always be too strong to call tasty but it will give you an idea.
As far as time in the brine, that will vary a lot depending on the type of meat. Something small (A cut of chicken or a fillet of Salmon) can be cured in 8-12 hours. Something large (A Ham) may take 7-10 days. Also anything thicker than 2 inches should have brine pumped into it. We use, shockingly enough, a brine pump for this. It is a giant syringe like device, but with a needle about the size of a large nail, only longer. No you won’t want any flu shots with this. You pump it up like a beach ball and put it down in the brine. This is handy and recommended on hams, shoulders, and even loins.
After the meat is cured, you need to rinse it. For the large cuts, 1 1/2 – 2 hours under running water. It doesn’t need to be running at full tilt, just a light flow around it. In the meat business we use a sink that over flows into another sink, so the meat is immerse. You can use a container that can overflow into you kitchen sink or (raised eyebrow time) a container set in the bath tub overflowing into the tub. (There go the brownie points with the wife) You get the idea, use your imagination and have some good excuses ready.
And finally, you cook it up. An oven will work fine. Set it at about 225 and figure on 6 hours although it could take 8. A meat thermometer is critical here. Small or thin cuts will cook much faster, probably in 3 -4 hours. When it gets to 165, its ready. Remember in lost cases it will be heated up again, so don’t expect this to look like dinner. Smaller cuts may be ready to throw on a plate but the larger cuts normally are going to be cooked again. If you find the outside is getting too well done before the temperature gets to your target, then cut the temperature back to 210 or so. Adjustment is the name of the game.
Smoked meat is a lot of work, but it is very rewarding. I highly recommend that you write down exactly what you do to make your product. It will make adjusting your recipe much easier and since there are so many steps it can be hard to remember what you did a week ago when you made that brine.
